• Required reading for all forum users!!!

    Welcome!
    Register to access the full functionality of the GSResources forum. Until you register and activate your account you will not have full forum access, nor will you be able to post or reply to messages.

    A note to new registrants...
    All new forum registrations must be activated via email before you have full access to the forum.

    A Special Note about Email accounts!
    DO NOT SIGN UP USING hotmail, outlook, gmx, sbcglobal, att, bellsouth or email.com. They delete our forum signup emails.

    A note to old forum members...
    I receive numerous requests from people who can no longer log in because their accounts were deleted. As mentioned in the forum FAQ, user accounts are deleted if you haven't logged in for the past 6 months. If you can't log in, then create a new forum account. If you don't get an error message, then check your email account for an activation message. If you get a message stating that the email address is already in use, then your account still exists so follow the instructions in the forum FAQ for resetting your password.

    Have you forgotten your password or have a new email address? Then read the forum FAQ for details on how to reset it.

    Any email requests for "can't log in anymore" problems or "lost my password" problems will be deleted. Read the forum FAQ and follow the instructions there - that's what we have one for...

  • Returning Visitors

    If you are a returning visitor who never received your confirmation email, then odds are your email provider is blockinig emails from our server. The only thing that can be done to get around this is you will have to try creating another forum account using an email address from another domain.

    If you are a returning visitor to the forum and can't log in using your old forum name and password but used to be able to then chances are your account is deleted. Purges of the databases are done regularly. You will have to create a new forum account and you should be all set.

'82 GS450 has gone dead

  • Thread starter Thread starter mdelio
  • Start date Start date
M

mdelio

Guest
So I picked up an 82 gs450L recently. Did a basic tune up on it and it ran great for days. Suddenly with no warning, nothing happens when I turn the ignition key. No lights, nothing. The battery is fine, and as far as I can tell, all the wires seem fine. I can't seem to find any fuses aside from an inline directly connected to the battery. That fuse is fine.

Any ideas?

Thanks.
 
Check the ground side of the wiring. I had problems with the GS400 and found the ground wire corroded. The fuse you found is all there is!

SV
 
I should have added that in my last post. All ground wires seem ok. I'll check all the wiring again, but I was curious to know if it might be something defective.

Thanks
 
OPen up the headlight bucket and find the connector for the ignition switch. Jump the red and orange wires and see if you get any life. The brown wire goes to the tail light for parking light action.

If you get life out of this test replace the ignition switch.
 
This advice is almost universally preceded by some sort of "I'm not trying to insult anyone's intelligence" disclaimer..

Is there a kill switch on the bars, that may be in the OFF position?

I've turned my key a few times with no results, freaked out for a few seconds, before realizing that I had leaned on the switch.

Not sure of the setup of your bike, or that it even has one, but I thought I'd throw it out there.
 
HOW DO YOU KNOW THE BATTERY IS FINE? DID YOU TEST IT OR DID YOU ACCIDENTLY LEAVE THE POWER ON AND DRAIN THE BATTERY? ALSO WHN I BOUGHT MY 750 OFF SOME GUY I NOTCED HE RIGGED A TOGGLE SWITCH WHICH BY FLICKING CUT OFF ALL THE POWER. CHECK FOR SOME MODIFICATIONS. IF NOT REFER TO A WIRING DIAGRAM AND MAKE SURE EVRYTHING IS HOOKED UP RIGHT.
 
Take your meter and make sure the engine is grounded well. On my '81 GS450, someone had pulled the motor and painted it, so it had a really crappy ground.

I would then take the meter and wiring diagram and just start going down the line of the electrical system. Once you get somewhere where the voltage stops, there is the problem. On mine, I had a molex that plugged in at the steering head (under the front of the gas tank) crack apart but it was inside a cover so it was not obvious. Once I started tracking the voltage I found it in about 10 minutes.
 
A key point here is to use a voltmeter to troubleshoot, not a creditcard, new battery, voodoo dolls, or even what "someone else had go wrong" because every electrical problem has the potential to be different than someone elses. A voltmeter is a must have for GS bike work and radio shack sells them starting at 10 bucks.

The trick is to isolate the problem. Everything does not just go bucko bazoo at once. Dead bikes are pretty easy since you'll be able to find the problem eventually. The intermittant problems are a bitch since you can't fix it if it is not acting up.
My money is on the ignition switch or the connectors that feed it.
 
Yep, mine was intermittent and drove me crazy for weeks. The break on the molex was internal, so the terminals inside were moving around. Found it once I started testing down the line with the meter. Pulled the molex apart to test and it crumbled in my hands. Meter and patience is the only answer.
 
You must log in or register to reply here.
Back
Top