Announcement

Collapse
No announcement yet.

1983 GS550ES Revs out of control when it gets hot

Collapse
X
 
  • Filter
  • Time
  • Show
Clear All
new posts

    1983 GS550ES Revs out of control when it gets hot

    Hi All,

    This is an extension of my previous forum post but since that was in the fuel delivery section I figured I would start a new thread here. Here is a link to the previous thread for any who want to read about this disaster of a motorcycle and what we have tried on it. https://www.thegsresources.com/_foru...Delivery-Issue

    So basically Chris and RPhillips were right in that the size 40 pilots were not the issue on this. I replaced them and tried adjusting the idle stop screw and I also tried adjusting the air fuel mixture screws, but whenever this bike gets really hot it revs out of control to 5k and beyond. The hotter it gets the higher it revs essentially. I thought I would do another check for a vacuum leak and this time instead of a propane torch I used a fog machine to see if I could see any smoke coming out of the exhaust but there was nothing. No change in idle or noise and I couldn't see anything being sucked in. When the bike was only slightly warm i took it for a ride thinking i fixed the problem after replacing the jets and it was really having a hard time getting any power in the 1-4K rpm range until it warmed up. This was with the 35 pilot jets and the factory 2.5 turns on the air fuel screw. I really do not think this is an issue with the carbs at this point because it runs the exact same with the 40s as it does with the 35s. Is there anything in the timing i should maybe check? I was reading about a guy with a 93 Ducati who had the same problem and someone mention ignition advance causing this issue. Again I'm grasping at straws here as usual but this makes no sense why it should not be running. Thanks for all the help in advance.

    -Joe

    PS:gs550es.jpg picture attached of bike

    #2
    Where are you looking for vac leaks??? At the base of intake manifolds? I've seen that before, or if they get severe cracks...
    '82 & '83 GS1100e

    Comment


      #3
      The ignition advance is built into the ignitor. Those boxes typically either work or not. It's rare for the ignitor to malfunction.
      Ed

      To measure is to know.

      Mikuni O-ring Kits For Sale...https://www.thegsresources.com/_foru...ts#post1703182

      Top Newbie Mistakes thread...http://www.thegsresources.com/_forum...d.php?t=171846

      Carb rebuild tutorial...https://gsarchive.bwringer.com/mtsac...d_Tutorial.pdf

      KZ750E Rebuild Thread...http://www.thegsresources.com/_forum...0-Resurrection

      Comment


        #4
        Have you replaced the o-rings p/n 23 at head/manifold interface?

        Shop online for OEM Cylinder Head parts that fit your 1983 Suzuki GS550ES, search all our OEM Parts or call at 386-740-2452
        1981 gs650L

        "We are all born ignorant, but you have to work hard to stay stupid" Ben Franklin

        Comment


          #5
          Speaking generally - if it happens as it gets hotter it would suggest a weak mixture/ air leak or throttle not closing. Did you check for play/wear in the throttle shafts - become unreliable in closing and get worse as carbs heat up, also let air in? Ive seen this on old CV carbs on cars. Just a thought

          (I had similar symptoms and found carbs out of balance and 1 badly leaking manifold. Gave the carbs a good clean up & balanced, siliconed the manifold and problem fixed)

          1982 GS550Ez, 1980 Yam RD350LC 4L0, 1980 Yam DT175,
          1977 Yam RD250D(Sold)
          London UK

          Comment


            #6
            Revert carbs to stock
            Replace internal seals. Robert barr has good cost effective stuff.
            Replace manifold seals. Robert barr has good cost effective stuff.
            Set valves to spec.
            Report results
            It worked in Hammamatsu return to the egg. These were the poor child of their class there was little available to make one suspect there are any exotic internals thwarting you.
            Propane? smoke machine? Hmmmmm. No mirrors? Borders on the whore in a fit method of coping with a problem.
            1983 GS 550 LD
            2009 BMW K1300s

            Comment

            Working...
            X