clutch slip

Collapse
X
 
  • Time
  • Show
Clear All
new posts
  • suzukibandit

    #1

    clutch slip

    Oki have a gs550mz katana and when i fire the bike up and go to drive it the clutch slips pretty bad but after about 20 mins of driving carefully the clutch grabs good and i can ride it normal without babying the clutch.So what the hell is going on i have freeplay in the cable and i blasted the metal plates and the fiber ones are in spec.Soim at a loss here trying to figure out whats going on can anyone help?
  • Big T
    Forum LongTimer
    Past Site Supporter
    Super Site Supporter
    • Mar 2005
    • 12392
    • West Slope, OR

    #2
    Did the bike sit for a long time?

    Did you scuff up the fiber plates with sandpaper?

    Springs within spec?
    1978 GS 1000 (since new)
    1979 GS 1000 (The Fridge, superbike replica project)
    1978 GS 1000 (parts)
    1981 GS 850 (anyone want a project?)
    1981 GPZ 550 (backroad screamer)
    1970 450 Mk IIID (THUMP!)
    2007 DRz 400S
    1999 ATK 490ES
    1994 DR 350SES

    Comment

    • SqDancerLynn1

      #3
      Did you replace the clutch springs ? What kind of oil are you using

      Comment

      • suzukibandit

        #4
        spring are in spec the bike did sit but i did a poor mans resto on it i blasted the metal plates and no i didnt scuff the fiber plate should i have? also i work for a vintage graphics company and my boss has quite a few old bike and he said that i shouldnt have put synthetic oil in my bike as the old ones werent made to run with it is he right?

        Comment

        • Guest

          #5
          Clutch cables actually stretches a bit when it gets hot. Does the cable go behind the engine and pick up all that heat? If so I'd say it's an adjustment problem.

          Comment

          • suzukibandit

            #6
            ya thats what my boss said so he played with it and it got worse

            Comment

            • Big T
              Forum LongTimer
              Past Site Supporter
              Super Site Supporter
              • Mar 2005
              • 12392
              • West Slope, OR

              #7
              Originally posted by suzukibandit
              my boss has quite a few old bike and he said that i shouldnt have put synthetic oil in my bike as the old ones werent made to run with it is he right?
              No, he's not

              Oil doesn't care how old your bike is - it's still lubricates. Rotella synthetic is used by many members here

              It does sound like a routing issue. Get a service manual and confirm the clutch cable is routed correctly. Check Cliff's site
              1978 GS 1000 (since new)
              1979 GS 1000 (The Fridge, superbike replica project)
              1978 GS 1000 (parts)
              1981 GS 850 (anyone want a project?)
              1981 GPZ 550 (backroad screamer)
              1970 450 Mk IIID (THUMP!)
              2007 DRz 400S
              1999 ATK 490ES
              1994 DR 350SES

              Comment

              • blowerbike
                Forum Guru
                GSResource Superstar
                • Aug 2008
                • 7057
                • Ohio Closer to KY Than Cleveland

                #8
                worm gear needs adjusted.
                does this model have a lever on the clutch cover where the cable attaches?
                if not it has a worm gear on the sprocket cover behind a small inspection plate.
                run in lightly/bottom out/back off 1 to 1-1/2 turns/jam nut down.
                readjust handlebar lever.

                Comment

                • koolaid_kid

                  #9
                  If you work on the worm drive, I suggest cleaning it first. Take the shifter off, remove the sprocket cover, remove the worm drive. Take it apart, clean all the junk out of it, regrease the worm gear, and reassemble. They tend to get clogged with junk over time and become problematic.

                  Comment

                  • mlinder

                    #10
                    Which synthetic oil did you use? Someone mentioned rotella, but I don't think it was you.

                    Comment

                    • Rover
                      Forum Sage
                      Past Site Supporter
                      • Mar 2009
                      • 1537
                      • Central Mass.

                      #11
                      I vote that its the synthetic oil.
                      http://i632.photobucket.com/albums/u...00080021-1.jpg
                      1978 GS1000C
                      1979 GS1000E
                      1980 GS1000E
                      2004 Roadstar

                      Comment

                      • Smokinapankake

                        #12
                        So long as the oil was not labeled "energy conserving" or something it should be okay.
                        I vote cable/worm/rack n pinion (if it has one).

                        Comment

                        • mlinder

                          #13
                          That's why I asked which synthetic he used.

                          Comment

                          • suzukibandit

                            #14
                            i used mobile one 20-50 and ive played with the cable oiled it and it still slips soim going to look at the clutch plates next

                            Comment

                            • mlinder

                              #15
                              Mobile One Motorcycle, or just Mobile One?

                              Comment

                              Working...