thanks in advance
Announcement
				
					Collapse
				
			
		
	
		
			
				No announcement yet.
				
			
				
	
Arg air box...
				
					Collapse
				
			
		
	X
- 
	
	
	
		
	
	
		
		
		
		
		
		
		
	
	
 Arg air box...Ok so i gotta pull and rebuild the carbs for my gs 750... Someone fill me in on how the heck ya get that nightmare of an air box outta da damn way?
 
 thanks in advanceTags: None
 
- 
	
	
	
		
	
	
		
		
		
		
		
		
		
	
	
 You need to loosen the air filter box, loosen the intake c-clamps and the air box c-clamps, then take out the carbs.....simple eh taking the carbs out is the simple parts......putting them back in is another matter.
							
						Rob taking the carbs out is the simple parts......putting them back in is another matter.
							
						Rob
 1983 1100ES, 98' ST1100, 02' DR-Z400E and a few other 'bits and pieces'
 Are you on the GSR Google Earth Map yet? http://www.thegsresources.com/_forum...d.php?t=170533
 
- 
	
	
	
		
	
	
		
		
		
		
		
		
		
	
	
 I don't remember the specifics of your bike, but it might help to loosen the front half of the rear fender, then loosen the air filter box and slide it back toward the fender.
 
 Just in case you did not know, the plastic part of the rear fender has a couple of tabs, much like the side covers, that push into grommets in the frame. Push the two sides of the fender toward each other, the tabs will pop out, allowing you to move the fender back about half an inch. Yeah, it's not much, but it's enough to help get the carbs out.
 
 .sigpic
 mine: 2000 Honda GoldWing GL1500SE and 1980 GS850G'K' "Junior"
 hers: 1982 GS850GL - "Angel" and 1969 Suzuki T250 Scrambler
 #1 son: 1986 Yamaha Venture Royale 1300 and 1982 GS650GL "Rat Bagger"
 #2 son: 1980 GS1000G
 Family Portrait
 Siblings and Spouses
 Mom's first ride
 Want a copy of my valve adjust spreadsheet for your 2-valve per cylinder engine? Send me an e-mail request (not a PM)
 (Click on my username in the upper-left corner for e-mail info.)
 Comment
- 
	
	
	
		
	
	
		
		
		
		
		
		
		
	
	
 Loosen everything up, Pull out the filter part of the air box, make sure the mounting blots for the front box are taken off, now loosen all the carb clamps front and back. push air box back as far as you can. this breaks the seal on the carb. break the seal on the throat rubber boots , remove the outer most boots. then wiggle out the carbs, oh yeah remove the throttle and choke cables. Takes a bit of work to angle them out. Stick some rags in the head openings so you don't loose something. To reinstall, slide the carbs back in, fit the carbs into the rubber boots of the air box and tighten some, then start in the middle with the carb boots and make sure the boots align then do the two outside boots. Check alignment and tighten everything down. Use a bit of silicone spray on the inside of the boots to make it easier to get the boots on the carbs. New rubber boots make the job much better. Chances are you probably need them anyways.sigpicMrBill Been a GSR member on and off since April 2002
 1980 GS 750E Bought new in Feb of 1980
 2015 CAN AM RTS
 
 
 Stuff I've done to my bike:dancing: 1100E front end with new Sonic springs, 1100E swing arm conversion with new Progressive shocks installed, 530 sprockets/chain conversion, new SS brake lines, new brake pads. New SS fasteners through out. Rebuilt carbs, new EBC clutch springs and horn installed. New paint. Motor runs strong.
 Comment
- 
	
	
	
		
	
	
		
		
		
		
		
		
		
	
	
 A good reason to get pods.Originally posted by mrbill5491 View PostLoosen everything up, Pull out the filter part of the air box, make sure the mounting blots for the front box are taken off, now loosen all the carb clamps front and back. push air box back as far as you can. this breaks the seal on the carb. break the seal on the throat rubber boots , remove the outer most boots. then wiggle out the carbs, oh yeah remove the throttle and choke cables. Takes a bit of work to angle them out. Stick some rags in the head openings so you don't loose something. To reinstall, slide the carbs back in, fit the carbs into the rubber boots of the air box and tighten some, then start in the middle with the carb boots and make sure the boots align then do the two outside boots. Check alignment and tighten everything down. Use a bit of silicone spray on the inside of the boots to make it easier to get the boots on the carbs. New rubber boots make the job much better. Chances are you probably need them anyways. 1982 GS1100E V&H "SS" exhaust, APE pods, 1150 oil cooler, 140 speedo, 99.3 rear wheel HP, black engine, '83 red 1982 GS1100E V&H "SS" exhaust, APE pods, 1150 oil cooler, 140 speedo, 99.3 rear wheel HP, black engine, '83 red
 
 2016 XL883L sigpic Two-tone blue and white. Almost 42 hp! Status: destroyed, now owned by the insurance company. The hole in my memory starts an hour before the accident and ends 24 hours after.
 Comment
- 
	
	
	
		
	
	
		
		
		
		
		
		
		
	
	 Crankthat Crankthat
 What Mr Bill said.Originally posted by mrbill5491 View PostLoosen everything up, Pull out the filter part of the air box, make sure the mounting blots for the front box are taken off, now loosen all the carb clamps front and back. push air box back as far as you can. this breaks the seal on the carb. break the seal on the throat rubber boots , remove the outer most boots. then wiggle out the carbs, oh yeah remove the throttle and choke cables. Takes a bit of work to angle them out. Stick some rags in the head openings so you don't loose something. To reinstall, slide the carbs back in, fit the carbs into the rubber boots of the air box and tighten some, then start in the middle with the carb boots and make sure the boots align then do the two outside boots. Check alignment and tighten everything down. Use a bit of silicone spray on the inside of the boots to make it easier to get the boots on the carbs. New rubber boots make the job much better. Chances are you probably need them anyways.
 The Airbox has a couple of bolts up top that attach it to the frame.
 They are located under the plate on top.
 I marked general area in red.
 [IMG] [/IMG] [/IMG]
 Comment
- 
	
	
	
		
	
	
		
		
		
		
		
		
		
	
	
 Not even, couldn't give me pods.Originally posted by Rob S. View PostA good reason to get pods. sigpicMrBill Been a GSR member on and off since April 2002 sigpicMrBill Been a GSR member on and off since April 2002
 1980 GS 750E Bought new in Feb of 1980
 2015 CAN AM RTS
 
 
 Stuff I've done to my bike:dancing: 1100E front end with new Sonic springs, 1100E swing arm conversion with new Progressive shocks installed, 530 sprockets/chain conversion, new SS brake lines, new brake pads. New SS fasteners through out. Rebuilt carbs, new EBC clutch springs and horn installed. New paint. Motor runs strong.
 Comment
.png)
Comment