GS750 alternator

[Guest]

Hi all. I have bought a replacement alternator which is installed in the cover, the wires colours don't match the ones i removed, my question is can any of the 3 wires from the stator connect to any of the 3 in the wiring loom or do i have to strip the wires back and trace them to match how it was set up before? 1977 8 valve GS750B.
Thanks in anticipation
Andy

[Guest]

i forgot to add, it has a newtronics regulator / rectifier which has 3 yellow wires but i marked them when removing the old alternator

[Nessism]

Stator wires have no specific order. Before you hook it up you should remove the wiring that sends one leg of the stator up to the headlamp switch. This is much discussed here and considered an important improvement.

[fastbysuzuki]

[Redman]

Short answer to your question: yes , doesn’t matter which stator wire.


To say what others have said: the three stator wires are essentially the same. An aftermarket stator will have the wire colors the same because it doesn’t matter the order they are connected.
when say to bypass the headlight switch (weither you have one or not) that means to connect the 3 stator wires directly to the 3 wires to the R/R (find harness going to r/r) Which will leave two wires of the bike harness (up to headlight shell) hanging loose.

(an alternator is something different, these bikes have magnets spinning on rotor and a stator which is 3 coils of wire and a regulator/rectifier)

[Grimly]

(an alternator is something different, these bikes have magnets spinning on rotor and a stator which is 3 coils of wire and a regulator/rectifier)

An alternator, producing alternating current.

[Guest]

Thanks

[Guest]

much appreciated

[Guest]

cheers for that

[Guest]

thanks, i don't know about the regulator yet, i just found a crack in the crankcases ,oil is leaking out so its going to be a full engine re build unless i can find a replacement somewhere

[Redman]

. . . . . . . . . . . . i just found a crack in the crankcases ,oil is leaking out . . . . . . .. . .

DOAHHhhhhh